Van drivers carrying out critical COVID-19 work encouraged to look after their own health

VW Vans

Key workers are being urged to look after their own health behind the wheel during the COVID-19 crisis, as on average 70% of van drivers are forced off work due to back pain each year, according to research from Volkswagen Commercial Vehicles*.

Volkswagen Commercial Vehicles has once again partnered with the British Chiropractic Association (BCA) to provide van drivers with some top tips and advice to avoid developing back issues as they put in long hours to keep UK residents safe and well.

Delivery drivers and tradespeople have been listed by the UK government as “key workers” who should continue to work throughout the COVID-19 crisis; and many are now expected to work extended hours to ensure supplies, services and help is provided across the country.

Figures show that 70% of van drivers suffer from back pain and often have to take as much as three weeks off work a year to recover*. Poor seat adjustment could be to blame for triggering back issues, especially as even under normal circumstances drivers will spend up to seven hours a day in their vans.

As part of the research carried out by Volkswagen Commercial Vehicles and the BCA, it was revealed while half of van drivers say they adjust their seat to the correct position, two-thirds are still sitting incorrectly or missing crucial steps**. Among the most common mistakes were positioning the seat too close to the steering wheel and angling the seat too far back.  

Prab Chandhok, chiropractor and BCA member, commented: “With an increase in the number of people supporting the national effort to provide essential deliveries and relay important supplies to organisations such as hospitals, supermarkets, food banks and pharmacies, it is very important drivers also consider their own health and wellbeing to be able to help more. Long hours spent in a vehicle can cause aches and pains, but there are simple steps individuals can take to better look after their back health when driving.”

As part of the Volkswagen Commercial Vehicles’ Working With You brand promise, it has partnered with the BCA to offer ten top tips to avoid back pain:

In the van:

  1. Height: Your thighs should be as parallel to the floor as your seat will allow, and where possible try to get your hips higher than your knees. You should also adjust the thigh support if you have one to ensure you have the maximum surface of your thighs touching the seat.
  2. Pedals: You should be able to push the pedals to the floor with a bend in your knees.
  3. 110°: Bring your seat all the way up so it’s straight and then take it back until you are comfortable whilst maintaining a 110 degree angle between your back and thighs.
  4. Lumbar Support: Only if required, the lumbar support should be adjusted so you can feel it support the hollow in your back but so it’s not causing your spine to arch more than is normal for you.
  5. Head Restraint: The height and angle of your head restraint should be adjusted so you can feel the centre of the support touch the middle of the back of your head, although it does not need to be touching at all times, as long as no more than 2cm away.
  6. Steering Wheel: Once in correct seating position, bring your arm up in front of you and position the centre of the steering wheel to be in line with the fold of your wrist.
  7. Rear Mirror: Lift up your chest by five degrees and then adjust your mirrors to help stay in an upright position on long drives.

Outside the van:

  1. Regular Breaks: It is crucial you take regular rest periods or at least mini breaks within each 45-60 minutes of sitting. This allows your body to adopt a new position by standing/moving and giving your tissues a break from becoming tight in a loaded sitting position.
  2. Exercises: Each time you stop, try to find a safe spot outside the vehicle to perform 5–10 knee bends by raising your knees past 90 degrees in front of you, allowing the leg muscles to stretch a little. If you don’t have any existing foot, ankle, knee or hip issues, try performing 3-5 simple squats, bending just below a seated position that is comfortable for you to get movement into your leg muscles. When you get home, you can also perform all of these exercises before relaxing.
  3. Remedies: A warm bath or shower can help relax your muscles after a long day and while the jury is out on Epsom/magnesium salts some find them useful to help replenish the minerals used by their muscles during the day. Following that, if you still feel soreness, you can try a gel ice pack or even a bag of peas wrapped in a suitable cover and apply it in the area of soreness for 10–15 minutes.***

Claire English, Head of Fleet at Volkswagen Commercial Vehicles, said: “Due to the increased demand to provide essential supplies and services throughout the COVID-19 crisis, we are aware that many van drivers might be spending extended hours in their vans adding to the risk of back pain.

“We’re proud to stand by our Working With You brand promise, aiming to create the smoothest and most comfortable journey possible for van drivers and in turn avoid downtime. We hope that these expert tips and advice from the BCA will help van drivers avoid back issues and support our customers’ crucial work through this difficult time.”

For more details on Volkswagen Commercial Vehicles’ award-winning range of products and services, or to find your nearest Van Centre.